Products

Home > Products

nickel ore magnetic concentration

  • Pre-concentration of nickel in laterite ores using

    2019-9-1 · Nickel is upgraded by 17% and 36% for ore S and I, respectively. There is no change in the nickel grade of ore L using the Falcon, similarly to what was obtained using the magnetic separation. The XRD analysis of the light fraction of the Falcon concentrator for the ore S and I samples is presented in Fig. 4. It seems that both particle size and particle density are affecting the separation using the Falcon concentrator.

  • Cited by: 12
  • Improvement of Copper–Nickel Ore Concentration

    2018-7-20 · The experimental research into intensification of copper–nickel ore concentration by flotation and magnetic separation shows that pretreatment of ore before milling by accelerated electrons results in the increased yield of –0.071 mm size and in enhanced

  • Cited by: 4
  • Calcination of low-grade laterite for concentration of

    In this study, a low-grade nickeliferous laterite ore was first calcinated and then processed by using a wet magnetic separator in order to recover nickel. Since, the ore contains both Ni and Fe, the calcination of laterite is effective in altering the crystalline structure of Fe species and therefore its magnetic properties, which in turn enable the selective concentration of nickel by magnetic separation that is an easy and

  • Cited by: 143
  • Calcination of low-grade laterite for concentration of

    2010-3-1 · In this study, the concentration of nickel from low-grade laterite was carried out by using a simple, cost-effective and environmentally-friendly process such as the wet magnetic separation. Since, the laterite ore usually contains Fe which has magnetic properties, the concentration of Ni is not an easy task. In order to enable the selective concentration of nickel by magnetic separation, the calcination of laterite was carried out prior to the magnetic

  • Cited by: 143
  • Upgrading low nickel content laterite ores using

    2012-5-20 · According to previous research, nickeliferous concentrates with nickel content of 5.1% and a nickel recovery of 98.8% could be produced from LN laterite ore by selective reduction and magnetic separation process when the reduction was conducted at 1250 °C for 60 min (Li et al., 2010). During the calcination, reduction of wustite was suppressed by the addition of silica through the formation of fayalite, allowing greater proportions of iron to be removed during the magnetic

  • Cited by: 110
  • Extraction of Nickel from Magnesia–Nickel Silicate Ore

    2021-4-29 · There are three main types of layers of the nickel silicate ore. The upper layer of the ore comprises an Fe and a Ni ore with a MgO content of ≤ 10%, accounting for 6.74% of the total reserves. The middle layer is composed of a ferruginous Ni ore containing 10–25% MgO,

  • [PDF]
  • Atmospheric pressure leaching of nickel from a low

    2018-6-27 · The effect of temperature on nickel dissolution from the laterite ore was investigated over a temperature range of 45–60 ºC at acid concentration of 5 M, stirring speed of 300 rpm, and L/S equal to 4 cm3/g. Higher leaching temperature generally leads to reduced batch time and increased extractions (MacCarthy et al., 2014, 2016). However, for some systems, it may be more economical to leach for a

  • [PDF]
  • Œ 176 PRECONCENTRATE OF NICKEL IN LATERITE ORES

    The laterite ore sample was also processed using only magnetic separation process. The results in Table 4 showed that the amount of nickel increased from 3.0% to 3.5% in the magnetic tailing (i.e

  • [PDF]
  • NICKEL AND COBALT ORES: FLOTATION 911 Metallurgist

    2016-6-7 · ores is through the production of nickel matte after enriching the nickel content of the ore. This is com-monly carried out by magnetic separation, Sotation, or a combinationof both after the ore is comminuted to below 200 m in size. The enrichment depends upon the degree of rejection of the other sulRde and non-sulRde gangue. The maximum grade of nickel

  • Preparation of magnetic composite adsorbents from

    2021-2-1 · With the depletion of sulfides and the increase of demand for nickel, laterite nickel ores, which is a low grade oxidized nickel mineral, has become an inevitable choice for nickel production (Butt and Cluzel, 2013). By calculation, taking pyrometallurgy of nickel as an example, 110 tons of waste slag will be obtained for each ton of nickel produced from laterite nickel ore (calculated by the ore grade of

  • Concentration Of Ores

    2021-6-23 · This removal process is known as concentration of ore. When a crushed ore containing nickel, This method is applicable to ferromagnetic ores and it is based on the difference in the magnetic properties of the ore and the impurities. For example tin stone can be separated from the wolframite impurities which is magnetic.

  • Œ 176 PRECONCENTRATE OF NICKEL IN LATERITE ORES

    The laterite ore sample was also processed using only magnetic separation process. The results in Table 4 showed that the amount of nickel increased from 3.0% to 3.5% in the magnetic tailing (i.e

  • Atmospheric pressure leaching of nickel from a low-grade

    2018-6-27 · Fig. 2. Polished sections of lateritic ore; a) main phase of sample, b) nickel in the rock matrix, c) association of the phases, d) nickel-containing minerals in rock matrix Table 3. The effect of magnetic separation on Ni concentration Fraction Weight percentage (%) Ni content (%) Feed 100 1.31 Concentrate at 0.12 T 1.42 0.594

  • NICKEL AND COBALT ORES: FLOTATION 911 Metallurgist

    2016-6-7 · ores is through the production of nickel matte after enriching the nickel content of the ore. This is com-monly carried out by magnetic separation, Sotation, or a combinationof both after the ore is comminuted to below 200 m in size. The enrichment depends upon the degree of rejection of the other sulRde and non-sulRde gangue. The maximum grade

  • KINETIC MODELS OF NICKEL LATERITE ORE

    The subject of this study is leaching process of nickel-bearing laterite ore from Ržanovo, R. Macedonia. The influence of sulfuric acid concentration (0.5, 1 and 3 M H2SO4) on the extracted Ni (%, wt.) was studied. The leaching process intensified by magnetic stirring at different temperatures (298, 323, 348 and 363 K) in the time interval of 120 min. was performed.

  • Ferronickel enrichment by fine particle reduction and

    2014-10-3 · Ferronickel enrichment and extraction from nickel laterite ore were studied through reduction and magnetic separation. Reduction experiments were performed using hydrogen and carbon monoxide as reductants at different temperatures (700–1000°C). Magnetic separation of the reduced products was conducted using a SLon-100 cycle pulsating magnetic

  • BENEFICIATION OF COPPER Et NICKEL ORES

    2011-8-5 · nickel contributed by the nickel sulphides like, millerite, violarite, pentlandite etc. These minerals are associated with either copper minerals or along with the other gangue present in the ore. Concentration of nickel sulphides alone was rather difficult due to their presence in minute quantity but were concentrated along with the copper

  • Chloridization and Reduction Roasting of High

    2015-10-15 · The chloridization and reduction roasting of high-magnesium, low-nickel oxide ore containing 0.82 pct Ni and 31.49 pct MgO were investigated in this study. Mineralogical investigation indicated that 84.6 pct of nickel was associated with silicates, and nickel was well distributed in mineral in the form of isomorphism. A series of chloridization tests with different added proportions of sodium

  • The life of Ni Nickel Institute

    The world’s nickel resources are currently estimated at almost 300 million tons. Australia, Indonesia, South Africa, Russia and Canada account for more than 50% of the global nickel resources. Economic concentrations of nickel occur in sulphide and in laterite-type ore deposits. Despite the fact that nickel mining has significantly increased over

  • Extraction of Nickel Nickel Ore Mining Mining

    2019-3-20 · Extraction of Nickel. This paper introduces the extraction of nickel process and characteristics of laterite nickel ore dressing, highlights the nickel ore crushing, washing in the nickel production process design.. 1 Description of nickel ore. The laterite nickel ore is complex in composition and can be roughly divided into two types: limonite type and silicon magnesium-nickel type.

  • Œ 176 PRECONCENTRATE OF NICKEL IN LATERITE ORES

    The laterite ore sample was also processed using only magnetic separation process. The results in Table 4 showed that the amount of nickel increased from 3.0% to 3.5% in the magnetic tailing (i.e

  • Atmospheric pressure leaching of nickel from a low-grade

    2018-6-27 · Fig. 2. Polished sections of lateritic ore; a) main phase of sample, b) nickel in the rock matrix, c) association of the phases, d) nickel-containing minerals in rock matrix Table 3. The effect of magnetic separation on Ni concentration Fraction Weight percentage (%) Ni content (%) Feed 100 1.31 Concentrate at 0.12 T 1.42 0.594

  • Ferronickel enrichment by fine particle reduction and

    2014-10-3 · Ferronickel enrichment and extraction from nickel laterite ore were studied through reduction and magnetic separation. Reduction experiments were performed using hydrogen and carbon monoxide as reductants at different temperatures (700–1000°C). Magnetic separation of the reduced products was conducted using a SLon-100 cycle pulsating magnetic

  • Nickel Geoscience Australia

    2021-7-2 · After mining, nickel ores are further processed to upgrade their nickel contents from 1-4% typical of the ores to concentrates with grades in the range 10-20%. Concentration involves crushing the ore and separating nickel-bearing from other

  • INTERNATINA SIENTII JRNA MAINES. TENGIES.

    Abstract: The subjecthis of t study is leaching process of nickel-bearing laterite ore from Ržanovo, R. Macedonia. The influence of sulfuric acid concentration (0.5, 1 and 3 M H2SO4) on the extracted Ni (%, wt.) was studied. The leaching process intensified by magnetic

  • BENEFICIATION OF COPPER Et NICKEL ORES

    2011-8-5 · nickel contributed by the nickel sulphides like, millerite, violarite, pentlandite etc. These minerals are associated with either copper minerals or along with the other gangue present in the ore. Concentration of nickel sulphides alone was rather difficult due to their presence in minute quantity but were concentrated along with the copper

  • Enhanced methods for nickel recovery from low

    The unique properties of nickel such as corrosion resistance, conductive and magnetic properties, and the capability for electromagnetic shielding, are what make nickel such a valuable resource. In the future, more recovery and recycling of nickel from secondary sources and low-grade ores will be even more important as ore

  • The life of Ni Nickel Institute

    The world’s nickel resources are currently estimated at almost 300 million tons. Australia, Indonesia, South Africa, Russia and Canada account for more than 50% of the global nickel resources. Economic concentrations of nickel occur in sulphide and in laterite-type ore deposits. Despite the fact that nickel mining has significantly increased over

  • nickel Ore SlideShare

    2016-1-28 · Sukinda Chromites Over Burden Analysis By NML- The average nickel concentration in the COB ore of Sukinda lies in the range of 0.4-0.7%. The existing deposit of COB ore in the Sukinda valley has been estimated to he around 140 million tonnes. Process for Nickel Enrichment- COB ore

  • Yan LIU vice-professor doctor Northeastern

    Magnetic composite adsorbent (MCA) was prepared successfully using laterite nickel ore. The effectiveness of MCA as an adsorbent was evaluated for removal trimethylamine from

  • 职位: doctor

    Copyright © 2004-2019 by SKD Machinery Technology Co. LTD All rights reserved.